XF series horizontal boiling dryer
Boiling dryers, also known as fluidized beds, are increasingly showing its important role in pharmaceutical, chemical, food, and grain processing. It consists of an air filter, a fluidized bed host, a cyclone separator, a bag filter, a high-pressure centrifugal fan, and an operating table. Due to the different properties of the dry materials, when supporting the dust removal equipment, it can be carried out as needed. Cyclone separators and bag dust collectors can be selected at the same time. You can also choose one of them. Generally speaking, materials with larger specific gravity need only choose cyclone separator. The lighter weight materials need to be equipped with a bag filter and equipped with a pneumatic feeding device. This equipment has two operation modes: continuous and gap.
The clean hot air is distributed into the bed through the valve plate, and the wet materials entering from the feeder are boiled by the hot air. Due to the wide contact between hot air and materials, the process of heat and mass transfer is increased, so it can be dried in a short time. If continuous type is used, the material enters from one end of the bed, and after boiling and drying for tens of seconds to minutes, it automatically flows out from the other end of the bed. This equipment is generally operated under negative pressure.
Drying of pharmaceuticals, chemical raw materials, food, food processing, feed. Such as: Drying and dehumidifying of API, tablet granules, traditional Chinese medicine granules, health food, beverage granules, corn germ, feed, plastic resin, citric acid and other powdery granular materials. The particle size of the applicable material is generally 0.1-6mm, and the optimal particle size is 0.5-3mm.
\ 项目 Model \ item
kg/h Drying capacity kg / h
kw Fan power kw
pa Wind pressure pa
m 3 /h Air volume m 3 / h
℃ Inlet air temperature ℃
J Maximum energy consumption J
3 5.5 × 10 3
8 2.0 × 10 8
、星形加料器 1.Star feeder
、气力自行输送 2.Pneumatic self-conveying
3 5.8 × 10 3
8 2.6 × 10 8
3 7.1 × 10 3
8 5.2 × 10 8
3 8.5 × 10 3
9 1.04 × 10 9
℃ 时测定，其它物料的干燥能力按具体干燥情况为准，选型时注意A 型：配旋风分离器； B 型：内袋式； C 型：既带旋风，又带布袋除尘器。 Note: The drying capacity is based on the initial moisture content of dried plum plum crystals of 20% and final moisture content of 5% . The inlet temperature is measured at 130 ° C. The drying capacity of other materials is subject to specific drying conditions. Pay attention to type A when selecting : Equipped with cyclone separator; Type B : inner bag type; Type C : both cyclone and bag dust collector.
All equipment should be placed flat and fixed with foot screws, and all parts are well sealed.
The fan can be placed outdoors or in a self-built silencing room. The floor plan can be adjusted according to the actual situation.